Interaction of 2-dodecylcyclobutanone (2-DCB) and internal standard in irradiated chicken jerkies and pig ears in solid-phase microextraction (SPME)-coupled gas chromatography-mass spectrometry (GC-MS) analysis.

The radiolysis of palmitic acid in chicken jerky (CJ) and pig ears (PE) can form 2-dodecylcyclobutanone (2-DCB). A solid-phase micro extraction-coupled GC-MS technique can be used for quantitative analysis of 2-DCB with the adequate use of an internal standard (IS). The objectives of this study are to: 1) investigate the IS and 2-DCB interactions as a function of IS concentration and irradiation dose; 2) elucidate the effects of bound 2-DCB; 3) use electron paramagnetic resonance spectroscopy to complement 2-DCB measurements. The measurement of 2-DCB formed by irradiation was significantly (P < 0.05) affected by the palmitic acid content and IS concentration. The amount of 2-DCB measured in irradiated (10 kGy) CJ and PE increased 70% and 300%, respectively, when the IS concentration increased from 8 to 800 ppb. Our findings serve as a guide for the adequate use of IS for quantitative analysis of 2-DCB formed in irradiated meat matrixes.

Efficiency of post-preparation treatment by gamma radiation to guarantee quality properties of plum molasses.

PURPOSE: This study aimed to assess specific gamma irradiation doses to be applied as a post-preparation process to assure the chemical, physical and sensory properties of plum molasses (PM). MATERIALS AND METHODS: Samples of PM were treated with 0, 3, 6 and 9 kGy in a 60Co gamma irradiation plant. Proximate composition, chemical, the physical and sensory determination was accomplished immediately after treatment. RESULTS: Our results showed that, the moisture content of PM were significantly (p < .05) rise by treating with 3 kGy. Whereas, ash and reducing sugar quantity of PM was significantly (p < .05) decreased by treatment at the same dose (3 kGy). Irradiation treatment induced small and not significant alterations (p > .05) in crude protein, crud fat, and total sugar of PM. The chemical and physical parameters including; total acidity (TA), pH, volatile basic nitrogen (VBN), total soluble solids (TSS) (%, Brix), viscosity and color, which were elected as the indicators of quality, were all well within the recommended values for PM treated with 0, 3, 6 and 9 kGy. Sensory determination indicated no significant (p > .05) alterations between irradiated samples and non-irradiated samples of PM. CONCLUSION: Irradiation treatment at 3 kGy was considered as acceptable to be used for the preservation purpose of PM without modifying their quality properties.

Effect and Mechanism of Eliminating Staphylococcus aureus by Electron Beam Irradiation and Reducing the Toxicity of Its Metabolites.

The purpose of this study was to evaluate the mechanism of sterilization of Staphylococcus aureus by electron beam irradiation (0.5-, 1-, 2-, 4-, and 6-kGy treatments) and whether it reduces the toxicity of its fermentation supernatant. In this study, we investigated the mechanism of sterilization of S. aureus by electron beam irradiation using colony count, membrane potential, intracellular ATP, and UV absorbance measurements; we used hemolytic, cytotoxic, and suckling mouse wound models to verify that electron beam irradiation reduced the toxicity of the S. aureus fermentation supernatant. The results showed that 2 kGy of electron beam irradiation treatment completely inactivated S. aureus in suspension culture, and 4 kGy inactivated cells in S. aureus biofilms. This study suggests that the bactericidal effect of electron beam irradiation on S. aureus may be attributed to reversible damage to the cytoplasmic membrane, resulting in its leakage and the significant degradation of genomic DNA. The combined results of hemolytic, cytotoxic, and suckling mouse wound models demonstrated that the toxicity of S. aureus metabolites was significantly reduced when the electron beam irradiation dose was 4 kGy. In summary, electron beam irradiation has the potential to control S. aureus and reduce its toxic metabolites in food. IMPORTANCE Electron beam irradiation of >1 kGy damaged the cytoplasmic membrane, and reactive oxygen species (ROS) penetrated the cells. Electron beam irradiation of >4 kGy reduces the combined toxicity of virulent proteins produced by Staphylococcus aureus. Electron beam irradiation of >4 kGy can be used to inactivate Staphylococcus aureus and biofilms on milk.

Use of Multiple Irradiations and Reference Materials as Comparators in Quality Control of Neutron Activation Analysis Data of Biological Samples.

We propose that several different reactor irradiation times followed by assaying of activity for differential counting periods may be employed for quality control (QC) of neutron activation analysis (NAA) data of biological samples. It is also recommended that three to four reference materials (RMs) of similar matrix but from different agencies such as National Institute of Standards and Technology (NIST, USA), International Atomic Energy Agency (IAEA, Vienna), Institute of Nuclear Chemistry and Technology (INCT, Poland), and National Institute of Environmental Studies (NIES, Japan) including a synthetic multielemental primary standard should always be analyzed simultaneously along with the samples. Finally, the mean ± σ values so obtained may be considered as more reliable after statistical analysis. Our analytical data for Na and K in three RMs (SRM 1572, CRM H-9, and Bowen's Kale) using different irradiation periods of 15 m, 2 h, 6 h, and 1 day were comparable with the certified values within error range of + 0.2 to - 2.7%. We report our data for 20 elements in two candidate RMs corn flour (INCT-CF-3) and soya bean flour (INCT-SBF-4) from the INCT, Poland, where Z-score values for most elements are in reasonable range of certified values.

[Detection of Gamma-Ray Irradiation History of Dried Plant-Based Foods via the Analysis of 5,6-Dihydrothymidine].

Irradiation is widely used worldwide to sterilize and kill insects in food, and prevent the germination of agricultural products. However, in Japan, food irradiation is prohibited except to prevent potato sprouting. Herein, 5,6-dihydrothymidine (DHdThd) residue-a damaged nucleoside generated from the thymidine (dThd) residue in DNA contained in food upon irradiation-was used as a detection indicator. Eight dried plant-based food samples were gamma ray-irradiated in the range from 3.2 to 8.3 kGy. Subsequently, DNA was extracted from the irradiated sample and digested into nucleosides by the three enzymes, and the test solution was analyzed by liquid chromatography tandem mass spectrometry (LC-MS/MS). Evidently, in all samples, the concentration ratio of DHdThd to dThd in the test solution (DHdThd/dThd) was dependent on the irradiation dose; moreover, during storage under frozen conditions for at least 890 d post-irradiation, this concentration ratio was equal to that immediately after irradiation. The irradiation histories of the eight types of dried plant-based food samples were correctly detected.

Impact of Gamma Irradiation and Kale Leaf Powder on Amino Acid and Fatty Acid Profiles of Chicken Meat under Different Storage Intervals.

The present study was planned to determine the effect of kale leaf powder and gamma rays on variations in the pH, amino acid and fatty acid profiles of chicken meat at different storage intervals. Significant changes (p ≤ 0.05) in the pH, amino acid and fatty acid profiles of chicken meat following different treatments (KLP (1% and 2%) and gamma irradiation (3k Gy)) were reported at 0, 7 and 14 days of storage. The pH value of the chicken meat sample decreased with the addition of kale leaf powder, whereas the value increased following a gamma irradiation dose of 3 kGy and with the passage of time. During different storage intervals, the minimum reduction in the amino acid and fatty acid quantities in the chicken meat samples was reported after gamma irradiation treatment. However, with the addition of KLP, the amount of amino acids and fatty acids in the chicken meat samples increased. Conclusively, the pH was observed to be reduced in the meat following combined treatment (irradiation + KLP), whereas the 2% KLP treatment improved the amino acid and fatty acid profiles of the chicken samples.

The attitude of Polish consumers toward food irradiation as one of the methods of food preservation.

Background: Food irradiation is one of the methods of food preservation. Unfortunately, despite many opinions from national and international organizations that confirm the safety of the irradiation technique, the irradiated food market is slowly developing, which is particularly noticeable in European countries, including Poland. Objectives: The main objective of this study was to determine the attitude of Polish consumers toward irradiated food and to find out whether familiarizing the respondents with educational materials on the irradiation technique would change their attitudes. Material and methods: In response to the objective of the study, an online survey (with the presentation of educational materials) was conducted with 609 respondents living in the Silesian Voivodeship, Poland. A specially prepared author's questionnaire was used, containing questions relating to: sociodemographic data, food preservation, food irradiation. An integral part of the survey was a multimedia presentation containing information about the food irradiation process. Results: A low level of knowledge about food irradiation was found--90.31% (n = 550) of the respondents had never heard of this method of preservation before. The percentage of respondents with a positive attitude toward radiation-preserved products increased significantly after providing informative material, from 6.20 (n = 38) to 67.16% (n = 409). The final attitude of the respondents toward irradiated food varied and depended on age, education and place of residence-positive attitudes toward irradiation predominated among those who were young (<30 years old), had a higher education and lived in cities >100,000 inhabitants. Educational materials also had a significant impact on consumers' interest in purchasing irradiated food-the percentage of people declaring a willingness to purchase this type of product increased from 19.20 (n = 117) to 59.30% (n = 361). Almost 60% of the respondents were willing to purchase irradiated foods. Women, on average, were more likely to be interested in purchasing irradiated food compared to men. Conclusions: The survey indicates that irradiated food could be commercially introduced in Poland, but on the condition that an effective educational program is planned.

Lipidomics profile of irradiated ground meat to support food safety.

Meat irradiation is considered as an effective treatment that expose the advantageous effects on meat preservation. This research, based on untargeted LC-HR orbitrap MS-based lipidomics strategy was meant to estimate the alterations in lipid profile of irradiated chicken, turkey and mixed (chicken, turkey and pork) ground meat in order to evaluate if exists any food safety issue concerning the lipidome alteration. Special attention was paid on oxidation triggered by irradiation. All three matrices exhibited a characteristic lipidome profile which was affected differently by five levels of irradiation intensity. Overall, 345 lipids categorized into 14 subclasses were identified. Remarkably, the oxidized glycerophosphoethanolamines and oxidized glycerophosphoserines were identified in irradiated turkey meat, while for all three categories a characteristic diacylglycerols profile was recognised. Our analytical approach highlighted that the estimation of qualitative variations in lipid portion might be valuable in food inspection purposes, especially when the samples from animal origin are suspected on irradiation treatment.

Low-dose gamma irradiation and pectin biodegradable nanocomposite coating containing curcumin nanoparticles and ajowan (Carum copticum) essential oil nanoemulsion for storage of chilled lamb loins.

The current investigation assessed the effect of pectin (PE) biodegradable nanocomposite coating containing curcumin nanoparticles (CNP) and ajowan (Carum copticum) essential oil nanoemulsion (ANE) combined with low-dose gamma irradiation on microbial, physiochemical, and sensorial qualities of lamb loins during refrigeration conditions. Active coating combined with gamma irradiation reduced the count number of mesophilic and psychrotrophic bacteria, lactic acid bacteria, Enterobacteriaceae; and minimized lipid and protein oxidation changes, total volatile basic nitrogen content, met-myoglobin formation, and color deterioration in the loin samples. The increased shelf-life of lamb loins up to 25 days compared with 5 days assigned for the control group can be associated with the application of ionizing radiation and edible PE coating containing CNP and ANE, which might be due to the synergistic or additive effects of treatments. Overall, as an effective preservation technique, a combination of PE + CNP + ANE and irradiation can be recommended for prolonging the shelf-life of lamb loins during refrigerated storage.

Immunomodulatory effect of metabolites from digested and fermented fractions from irradiated pineapple (Annanas comosus L.) snack-bars.

Phenolic compounds (PC), can modulate the immune response. UV-C irradiation, commonly used as a minimal processing method in fresh-foods to reduce the microbial load, increase shelf-life, provide a minimal processing and facilitate the release of PC. This study aimed to evaluate the effect of intestinal (IF) and fermented (FF) fractions of non-irradiated (NIPB) and irradiated (IPB) pineapple snack-bars on the production of nitric oxide (NO), interleukin 6 (IL-6), cyclooxygenase 2 (COX-2), and tumor necrosis factor-alpha (TNF-α) in mice macrophages. IF of NIPB and IPB exerted an immunomodulatory effect by promoting the production of NO (26 pg/mL) in both treatments, COX-2 (438 and 399 pg/mL), and TNF-α (778 and 802 pg/mL) for NIPB and IPB respectively. The TNF-α increased in IF of NIPB and IPB approximately 371 %, and in FF, only increased 132 %. The NO production was not different between IF and FF. COX-2 production was higher in FF.

Food irradiation: a promising technology to produce hypoallergenic food with high quality.

The increasing incidence of food allergy cases is a public health problem of global concern. Producing hypoallergenic foods with high quality, low cost, and eco-friendly is a new trend for the food industry in the coming decades. Food irradiation, a non-thermal food processing technology, is a powerful tool to reduce the allergenicity with the above advantages. This review presents a summary of recent studies about food irradiation to reduce the allergenicity of food, including shellfish, soy, peanut, milk, tree nut, egg, wheat and fish. Principles of food irradiation, including mechanisms of allergenicity-reduction, irradiation types and characteristics, are discussed. Specific effects of food irradiation are also evaluated, involving microbial decontamination, improvement or preservation of nutritional value, harmful substances reduction of food products. Furthermore, the advantages, disadvantages and limitations of food irradiation are analyzed. It is concluded that food irradiation is a safety tool to reduce the allergenicity of food effectively, with high nutritional value and long shelf-life, making it a competitive alternative technology to traditional techniques such as heating treatments. Of note, a combination of irradiation with additional processing may be a trend for food irradiation.

Thermoultrasonication, ultraviolet-C irradiation, and high-pressure processing: Novel techniques to preserve insulin in donor human milk.

BACKGROUND & AIMS: Donor human milk (DHM) is recommended as the first alternative for preterm infants if their mother's own milk is not available or if the quantity is not sufficient. The most commonly used technique to eliminate microbial contaminants in DHM is holder pasteurization (HoP). However, the heating process during HoP partially destroys milk bioactive factors such as insulin. Therefore, innovative techniques have been developed as alternatives to HoP. The objective of this study was to determine the effect of HoP, high-temperature-short-time (HTST), thermoultrasonication (TUS), ultraviolet-C irradiation (UV-C), and high-pressure processing (HPP) on the insulin concentration in DHM. METHODS: Milk samples from 28 non-diabetic mothers were collected. The milk samples were aliquoted and either left untreated or treated with HoP (62.5 °C; 30 min), HTST (72 °C; 15 s), TUS (60 W; 6 min), UV-C (4863 J/L), or HPP (500 MPa; 5 min). RESULTS: The mean insulin concentration in untreated milk was 79 ± 41 pmol/L. The mean insulin retention rate was 67% for HoP, 78% for HTST, 97% for TUS, 94% for UV-C, and 106% for HPP. The mean insulin concentration in milk treated with HoP was significantly lower compared to untreated milk (p = 0.01). CONCLUSION: TUS, UV-C, and HPP preserve insulin in DHM. The insulin concentration in DHM is affected to a larger extent by HoP than by HTST. These results indicate that TUS, UV-C, and HPP may serve as alternatives to HoP.

Growth temperature influences the resistance of Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium on lettuce to X-ray irradiation.

This study aimed to investigate the effect of different growth temperatures on the resistance of Escherichia coli O157:H7 and Salmonella Typhimurium to low-energy X-ray irradiation. Irradiation of contaminated phosphate-buffered saline with 0.6 kGy X-ray decreased the counts of E. coli O157:H7 cultured at 37 °C to below the detection limit (<1.0 colony-forming unit (CFU)/mL) and those of E. coli O157:H7 cultured at 25 and 15 °C by 4.82 and 4.45 log CFU/mL, respectively. The viable counts of S. Typhimurium cultured at 37, 25, and 15 °C in phosphate-buffered saline decreased by 3.56, 3.08, and 2.75 log CFU/mL, respectively, after irradiation with 0.6 kGy X-ray. Irradiation of contaminated lettuce with 0.4 kGy decreased the counts of E. coli O157:H7 cultured at 37, 25, and 15 °C by 3.97, 3.45, and 3.10 log CFU/cm2, respectively, and those of S. Typhimurium by 4.41, 3.84, and 3.40 log CFU/cm2, respectively. Growth temperature influenced pathogen resistance to X-ray irradiation by modulating cellular membrane and DNA integrity, intracellular enzyme activity, and efflux pump function. The results of this study suggest that the stress resistance status of pathogenic bacteria cultured at different growth temperatures should be considered for the application of X-ray irradiation for fresh produce sterilization.

Combined effects of irradiation and storage time on the nutritional and chemical parameters of dried Agaricus bisporus Portobello mushroom flour.

Portobello variety of Agaricus bisporus mushrooms, appreciated for its taste, makes it desirable to be eaten fresh and also as flour in soups and gravies. Gamma and electron-beam radiation at four doses (1, 2, 5, and 10 kGy) were used to analyze its preservation effect on Portobello mushroom flour. A proximate analysis, as well as the impact on fatty acids, tocopherols, soluble sugars, organic acids, and ergosterol profiles, were performed every 3 months, during a storage period of 1 year. Gamma rays preserved mannitol (most abundant soluble sugar) over the 12 months, while electron beam radiation preserved organic acids. No significant changes were sought for any radiation type, and the slight changes extracted from the estimated marginal means reveal a tendency for irradiation as having preserving effects of nutrients and other important molecules. Thus, both irradiation types, up to 10 kGy are suitable for preservation of A. bisporus Portobello flour.

High-Coverage Metabolome Analysis Reveals Significant Diet Effects of Autoclaved and Irradiated Feed on Mouse Fecal and Urine Metabolomics.

SCOPE: Using metabolomics to study the relations of nutrition and health requires stringent control of the experimental conditions used in an animal model. This work investigates the diet effects of autoclaved and irradiated feed on mouse urine and fecal metabolomics. METHODS AND RESULTS: C57BL/6 mice are fed normal-irradiation sterilized diet (n = 9), autoclave sterilized diet (n = 9), and high-irradiation sterilized diet (n = 9) for 4 weeks. Differential chemical isotope labeling liquid chromatography mass spectrometry is used to quantify the metabolome variations of urine and feces collected at five time points. Significant differences are observed in urine or fecal metabolomes of mice fed autoclaved diet versus mice fed high-irradiation diet or fed normal-irradiation diet, while the differences are small between the mice fed normal-irradiation and high-irradiation diet. Correlation studies of metabolite changes of diet- and aging-related biomarkers indicate a large overlap of significantly affected metabolites by the two factors. CONCLUSIONS: Diet can be a confounding factor that needs to be carefully considered when a metabolomics study is designed and metabolomic results of a mouse model of nutritional or other biological study are interpreted. Using the same sterilized diet for a given metabolomics project is essential to control the diet effect.

Use of optically stimulated luminescence (OSL) in the detection of irradiated spices.

In this study, the validity of using the optically stimulated luminescence (OSL) technique as a scanning method for the detection of irradiated foodstuffs was investigated. Gamma-irradiated thyme, mint and clove samples were stimulated with a continuous wave blue light (CW-OSL) and their OSL signal sensitivity and stability properties were measured. While no OSL signal was observed for all non-irradiated spices, a significant increase in the intensity of OSL signals was noted for all samples after irradiation with 5 kGy, 10 kGy and 20 kGy. It was also observed that the measured OSL signals were well above the background level even after one year of irradiation. It is therefore concluded that irradiated thyme, mint and clove samples can clearly be identified using the CW-OSL technique without any pre-treatment even one year after irradiation. This result indicates that, where spices contain sufficient silicate minerals, the CW-OSL technique could be used as a method for detecting irradiation.

Determination of pepper microbial contamination for low energy e-beam irradiation.

Electrons with energies of 300 keV or lower have the potential to decontaminate the surfaces of various types of food products with minimal loss of quality. The aim of the present work was to determine the thickness of the layer inhabited by microorganisms. The food samples tested were black and white pepper irradiated with 200 keV, 230 keV, 300 keV and 9 MeV beams of electron energy. To determine the depth from the surface which can be inhabited by microorganisms two approaches were tested. The methods used were based on the application of different microbiological recovery techniques and the microbial effectiveness of the irradiation process depending on the energy of the electron beam. It was observed that the layer which microorganisms may contaminate differed for the tested samples it was estimated as being below 100 µm thick for white pepper and about 200 µm for black pepper. The penetration ability was significant in experiments performed, and as a result the electron beam at the lowest levels tested (200 and 230 keV) was found to be insufficient to effectively decontaminate the black pepper samples. The beam of energy 300 keV was found to have a similar microbial inactivation effect as the high energy electron beam (9 MeV).

Inactivation of E. coli and L. innocua in milk by a thin film UV-C reactor modified with flow guiding elements (FGE).

In this study the suitability of a thin-film reactor (TFR) equipped with special flow guiding elements (FGE) was examined to analyse its capability to inactivate microorganisms in milk. Experiments were carried out with UHT-milk inoculated with Escherichia coli (E. coli), DH5α and Listeria innocua (L. innocua) WS 2258. Furthermore, the inactivation of microorganisms originally occurring in raw milk was investigated. E. coli, DH5α and L. innocua serving as biodosimeter were reduced by 4.58-log and 3.19-log, respectively. In milk, the original microorganisms showed a 4-log reduction. Without FGE the reduction was below 0.13-log. Thus, it can be derived that the efficacy of a UV-C thin-film reactor processing absorptive media like milk can be highly improved using FGE.

Electron Beam Susceptibility of Enteric Viruses and Surrogate Organisms on Fruit, Seed and Spice Matrices.

The objective of this study was to use high-energy electron beam (HEEB) treatments to find surrogate microorganisms for enteric viruses and to use the selected surrogates as proof of concept to investigate low-energy electron beam (LEEB) treatments for enteric virus inactivation at industrial scale on frozen blueberries. Six food matrices inoculated with HAV (hepatitis A virus), MNV S99 (murine norovirus), bacteriophages MS2 and Qß, and Geobacillus stearothermophilus spores were treated with HEEB at 10 MeV using 4, 8 and 16 kGy doses. G. stearothermophilus spores showed the highest inactivation on all matrices except on raisins, with a dose-dependent effect. HAV reached the maximum measurable log10 reduction (> 3.2 log10) when treated at 16 kGy on raisins. MNV showed the highest resistance of all tested microorganisms, independent of the dose, except on frozen blueberries. On frozen blueberries, freeze-dried raspberries, sesame seeds and black peppercorns, HAV showed a mean inactivation level in between those of MS2 and G. stearothermophilus. Based on this, we selected both surrogate organisms as first approximation to estimate HAV inactivation on frozen blueberries during LEEB treatment at 250 keV using 16 kGy. Reductions of 3.1 and 1.3 log10 were measured for G. stearothermophilus spores and MS2, respectively, suggesting that a minimum reduction of 1.4 log10 can be expected for HAV under the same conditions.

Impact of chlorine dioxide and electron-beam irradiation for the reduction of murine norovirus in low-salted "jogaejeotgal", a traditional Korean salted and fermented clam.

Clam jeotgal, called "jogaejeotgal," is a Korean fermented seafood product with, generally, a high amount of added salt to inhibit the growth of pathogenic microorganisms. This study aimed to evaluate the efficacy of chlorine dioxide (ClO2) and sodium hypochlorite (NaOCl) against murine norovirus 1 (MNV-1), a surrogate for human norovirus, in salt-fermented clam, jogaejeotgal. The sequential effect of ClO2 and electron-beam (e-beam) irradiation on the inactivation of MNV-1 was also investigated. Treatments of up to 300 ppm ClO2 and 1000 ppm NaOCl were used to determine the disinfectant concentrations at which more than 1 log (90%) MNV-1 inactivation occurred. The sequential treatment of ClO2 (50-300 ppm) and e-beam (1-5.5 kGy) was performed after storage at 4 °C for 7 days. There was a 1.9-log reduction of the virus in seasoned clams irradiated at 5.5 kGy after ClO2 treatment at 300 ppm. No significant change (p > 0.05) in physicochemical quality was observed after the combined treatment, suggesting the potential for the use of a combined treatment using ClO2 (300 ppm) and e-beam (5.5 kGy) in the jeotgal manufacturing industry for the reduction of norovirus.